低溫蒸發結晶

低溫蒸發結晶

低溫蒸發結晶整個系統將由真空泵抽成真空,蒸發室的真空度約爲95%~97%(表壓爲-0.095~-0.097mpa),在此條件下的蒸發溫度爲32℃~35℃。物料無需用泵,利用系統的負壓將物料吸進蒸發室,噴成霧狀,然後水分被蒸發,陳品通過離心泵循環進入蒸發室,達到要求的濃度後出料。

快播黄色电影詳情

一、低溫蒸發器的运行原理
the operating principle of low temperature evaporator

低溫蒸發結晶整個系統將由真空泵抽成真空,蒸發室的真空度約爲95%~97%(表壓爲-0.095~-0.097mpa),在此條件下的蒸發溫度爲32℃~35℃。物料無需用泵,利用系統的負壓將物料吸進蒸發室,噴成霧狀,然後水分被蒸發,陳品通過離心泵循環進入蒸發室,達到要求的濃度後出料。

濃縮液由于粘度較大,所以采用螺杆泵抽出。設備可在出口處配備一個測定儀,在不接觸負壓情況下根據介質密度,自動卸料,保證快播黄色电影的濃度控制。整個操作過程通過程序控制,操作簡單,節省人力。

The whole system consists of vacuum pump and vacuum evaporation chamber, the vacuum degree is about 95%~97% (g -0.095~-0.097mpa), evaporation temperature under the condition of 32 DEG ~35 deg. No need to pump material, making use of the system will be sucked into the negative pressure material evaporation chamber, spray into the mist, then the water is evaporated, Chen enters into the evaporation chamber by centrifugal pump, to achieve the required concentration after discharge.

Because of the viscosity of the concentrated liquid, so the screw pump. The equipment can be equipped with a measuring instrument at the outlet, which can automatically discharge the material according to the density of the medium without touching the negative pressure to ensure the concentration control of the product. The whole operation process is controlled by the program, the operation is simple, and the manpower is saved.

二、低溫蒸發器的优点
Advantages of low temperature evaporator

國內傳統的常規蒸發器一般都是分離式的,占地面積大,浪費空間。該設備無需使用蒸汽,直接接通水、電即可運行,節能環保。自帶熱泵循環,冷卻用水由系統自行補償産生,節約能源,減少工業廢水的處理費用。處理後的冷凝水可循環使用或達到零排放。富集的鹽分和重金屬等需另行處理。(委托第三方)

The traditional conventional evaporators in China are generally separated, which covers a large area and wastes space. The equipment does not need to use steam, directly connected to water, electricity can run, energy saving and environmental protection. With the heat pump cycle, cooling water by the system to generate their own compensation, save energy, reduce the cost of industrial wastewater treatment. The treated condensate can be recycled or used to achieve zero emissions. Enriched salt and heavy metals should be treated separately. (third party)

三、低溫蒸發器的特有技术
Special technology of low temperature evaporator

1.全自動控制,處理水質效果好,清潔無異味。
2.無需外加熱源,通過利用特種冷凝液運行的熱泵獲得必要的熱能,可比常規利用外加熱源的蒸發器節能50%,減少運營成本。也無需外接冷凝系統,節約循環冷卻水。
3.在不接觸負壓的情況下,根據介質密度測定,自動卸料。
4.設備上設有觀察窗,可隨時觀察蒸發情況。
5.設備運行的同時,可對蒸餾液和濃縮液進行取樣化驗。
6.設備性能穩定,連續運行。

1. fully automatic control, water treatment effect is good, clean no smell.
2. do not need external heat source, through the use of special condenser operation of the heat pump to obtain the necessary heat energy, can be more than the conventional use of external heat source evaporator energy saving 50%, reduce operating costs. No external condensation system is needed to save circulating cooling water.
3. in the absence of contact with the negative pressure, according to the medium density measurement, automatic discharge.
4. the equipment is provided with an observation window, and the evaporation can be observed at any time.
5. when the equipment is running, it can be used for sampling and analysis of distilled liquor and concentrate.
6. stable equipment performance, continuous operation.

四、低温真空蒸发器与多效蒸发器快播黄色电影能耗成本对比Comparison of energy consumption cost between low temperature vacuum evaporator and multi effect evaporator

上一條: 在線清洗

下一条: 无

詢盤